Material Safety Data Sheet - Belt-Dress (Aerosol) 
| IDENTITY (as used on label and list) |
|
|
SAF-T-EZE BELT DRESS |
| |
Manufacturers name
SAF-T-EZE DIV., STL COMPOUND CORPORATION
300 EISENHOWER LANE NORTH
LOMBARD, ILLINOIS, USA 60148 |
Emergency Telephone Number
Chemtrec 1-800-424-9300 |
Telephone Number for Information
630-495-2001 |
Date Prepared
NOVEMBER 01, 2006 |
| Section IIHazardous Ingredients/Identity Information |
Hazardous Components
(Specific Chemical Identity, Common Name(s)) |
OSHA PEL |
ACGIH TLV |
Other Limits Recommended |
% (optional) |
|
|
800 |
1000 |
|
|
| Aliphatic Hydrocarbon |
CAS# 64742-47-8 | |
500 |
500 |
|
|
| Dimethyl Ether |
CAS# 115-10-6 | |
N/A |
N/A |
|
|
| Hydrocarbon Resin |
CAS# 68131-77-1 | |
N/A |
N/A |
|
|
| DOT SHIPPING - CONSUMER COMMODITY ORM-D |
| All components of this product are listed on the Toxic Substance Control Act (TSCA) inventory of chemical substances maintained by the U.S. Environmental Protection Agency. |
| |
|
Section IIIPhysical/Chemical Characteristics |
| Boiling Point |
Wide Range |
Specific Gravity (H20 = 1) |
0.67 |
| Vapor Pressure (mm Hg) PSIG @ 70?F |
65-75 psi |
Melting Point |
N/A |
Vapor Density (AIR = 1)
Heavier than air |
>1 |
Evaporation Rate (Butyl Acetate = 1) |
N/A | |
| Solubility in Water |
Negligible |
| Appearance and Odor |
Brown semi-viscous liquid, solvent odor |
|
|
|
Section IVFire and Explosion Hazard Data |
| Flash Point (Method Used) |
T.C.C. -40?F | |
|
|
| |
| |
|
Extinguishing Media |
Use water fog, dry chemical or carbon dioxide |
| Special Fire Fighting Procedures |
Water may be used to keep fire exposed containers cool until fire is out. Use air supplied mask and procedure for chemical fires. |
| Unusual Fire and Explosion Hazards |
Heated cans may burst |
| |
| Section VReactivity Data |
| Stability |
Unstable |
|
Conditions to Avoid Open flames, sparks and high temperatures |
| Stable |
X | |
| Incompatibility (Materials to Avoid) |
Strong oxidizing agents |
| Hazardous Decomposition or Byproducts |
Carbon dioxide, fumes and smoke |
Hazardous
Polymerization |
May Occur |
|
Conditions to Avoid None |
| Will not Occur |
X | |
| |
| Section VIHealth Hazard Data |
| Route(s) of Entry: |
Inhalation?
Yes |
Skin?
Yes |
Ingestion?
Unlikely |
| Health Hazards (Acute and Chronic) |
Excessive inhalation of vapors can cause nasal and/or respiratory irritation. Contact with eyes may cause pain and irritation. Can cause severe irritation, redness, tearing, blurred vision. Skin contact may cause irritation on repeated exposure. Effects are reversible. Hexane may affect the central nervous system. |
| Carcinogenicity: |
|
|
Presently not on any list | |
NTP?
|
IARC Monographs?
|
OSHA Regulated
|
|
None of the ingredients in this product are on the IRC, NTP or OSHA list for carcinogenic hazards. |
| Signs and Symptoms of Exposure |
INHALATION: Dizziness, headache, possibly unconsciousness. CONTACT WITH EYES: Redness, tearing, blurred vision. SKIN: Irritation may be caused by repeated exposure. |
Medical Conditions Generally aggravated
by Exposure |
Alcohol consumed before or after exposure may increase adverse effects. |
| Emergency and First Aid Procedures |
EYES: Flush thoroughly with water, get medical attention. SKIN: Wash with soap and water. INGESTION: Do not induce vomiting, call physician. INHALATION: Remove to fresh air, if breathing has stopped, give artificial respiration & get medical attention. |
| |
| Section VIIPrecautions for Safe Handling and Use |
Steps to be Taken in Case Material is
Released or Spilled |
Soak up with absorbent material such as sand, earth, sweeping compound or some other absorbent material. Provide adequate ventilation. |
| Waste Disposal Method |
Dispose in accordance with Feral, State & Local regulations. Aerosol cans must be disposed of in an environmentally accepted manner due to their potential to present an explosion hazard. |
Precautions to be Taken
in Handling and Storing |
Store in cool (60-80?F) location away from direct sunlight & other sources of heat. Keep container tightly closed when not in use. |
| Other Precautions |
Use with adequate ventilation, avoid prolonged or repeated breathing of vapors. Avoid skin contact. Use normal good industrial hygienic practices. Do not smoke while using. |
| |
| Section VIIIControl Measures |
| Respiratory Protection (Specify Type) |
If TLV is exceeded, an approved air supplied respirator is advised. |
| Ventilation: |
|
|
| Mechanical (General) |
Acceptable | |
|
| Protective Gloves |
Solvent resistant | |
| Eye Protection |
Safety glasses of full face shield | |
| Other Protective Clothing or Equipment |
Safety shower and eye bath |
| Work/Hygienic Practices |
Wash hands thoroughly after handling. Do not direct spray toward face. |
The information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions. Any use of the product which is not in conformance with this data sheet or which involves using the product in combination with any other product or any other process is the responsibility of the user.
| |
